The failure mileage was 60,000. The leak came from the area where the high and low pressure lines connect to the steering rack. The approximate failure mileage was 156,000. This article applies to the Dodge Ram 2002-2008. This page was edited on: May 3, 2004. They can usually have the part for you within a couple days.
Steering Hoses,Power Steering,4 Wheel Drive With Hydrobooster MoparPartsGiant. We love when auto parts experts come to our site and we love when car parts newbies come to our site. Entering your vehicle information in our Year Make Model selector up top, helps ensure you get an auto part that fits your car, truck or other type of vehicle. I live in southwestern pennsylvania and the roads on which I travel are very steep and winding. While the vehicle was taken to an independent mechanic for an unrelated issue, the contact was informed that there was fluid leaking from the axle. The contact took the vehicle to the dealer where it was confirmed that the rack and pinion was leaking.
Here is a link to your The power steering pressure switch is installed in the power steering high-pressure hose Fig. As your Dodge Ram truck stacks up the miles, you'll begin to notice more play in the steering wheel. At the time the truck had 62000 kms and 3 months past it's warranty and has not been driven off road. I was just told by an auto repair man that my 2002 olds alero's power steering fluid can only be accessed and therefor filled by the dealer because of a special tool needed to open the compartment. There has been no accidents but one near miss when the truck veered over to the on coming lane after going over a bump. Not sure why there allowed to keep them on the streets being so dangerous to drive.
For any questions that you have rerngdiag interchangeable parts and which parts will fit which different vehicles, talk to the folks at your local wrecking yard. This will take the fluid from the rack and eventually bring it back to the reservoir. The Dodge dealer would not help cover any expenses for this premature failure. The contact stated that the steering wheel seized and could not be turned left. Dodge should take into account all of the incidents pertaining to this, and issue a recall for the repair before someone is not able to write a complaint like this. Fortunatly iwasn't driving the truck when this happened. In 2005 I notice power steering fluid leaking again in the same area and thought it was the hose again.
Step 5 — Refill the power steering reservoir with new fluid Pour fresh power steering fluid into the power steering reservoir until you reach the max line. The vehicle was not repaired. I had the dealer fix the rack and pinion both times. Sounds like Chrysler should be buying these trucks back so all there customers dont have to risk there lives driving down the road in a poor designed vehicle the produced. You may want to repeat this several times, it may take a long time, but will be cheaper than replacing the steering rack, box, pump, and lines. Remove additional fluid that has appeared from the steering wheel turn.
The failure mileage was 130,000 and the current mileage was 154,094. I use this truck to tow a 3200 pound travel trailer. As your Dodge Ram truck stacks up the miles, you'll begin to notice more play in the steering wheel. Very dangerous situation in traffic. No accident occurred in either instance, but very difficult to drive a truck home when you are still 400 miles from there with no power steering on a Sunday. Fill it half with half the bottle, then check the dipstick, then put in half of that half-bottle a quarter of the bottle in , check, and repeat until you get it to the appropriate level. The failure mileage was 80,134.
The contact also stated that the power steering fluid leaked continuously. You can use this in both conventional and synthetic oils. Pro Tip Your power steering fill cap is vented, so while you have it, why not give it a good scrubbing with soap and hot water to be certain the vent hole isn't clogged? Select an illustration to view its particular parts. And a big thank you goes to for making DodgeRam. Here's how to tighten it back up again. A variation may be observed from vehicle to vehicle due to manufacturing tolerance and refill procedure.
The loss of power steering on a vehicle this size, especially if towing a large load, could be, and probably would be very dangerous. Your power steering system helps you turn your steering wheel more easily. A funnel and paper towels help keep things neat and reduce smoking, as spilled fluids burn off the block. We have worked hard to design a site that caters to everyones Dodge Ram 2500 Power Steering Fluid needs. Once this happens, you'll notice the fluid level needs to be topped off.
Remove the cap from your power steering reservoir fill spout. Do not start the truck! The manufacturer was made aware of the failure. Will the rad need to be removed to make room? The manufacturer was made aware of the failure and offered no further assistance. Removal of the radiator will save you alot of back breaking and bending. This article applies to the Dodge Ram 1500 2007-2013.
Another way to access the fuel pump is to lift the box pickup bed up off of the frame. It terrifies me to think what may happen if this unit was to fail while I was navigating these roads. We're here to help you find that perfect Power Steering Fluid for your Dodge Ram 2500. The wind shield wipers only work on the highest setting and when turned off stop wherever on the windshield when you turn the switch to shut them off, the engine seems to be leaking oil some place, have had to replace both front wheel hub assembelies, rear end has foam in the fluid, im guessing from reading this that my rear axel is about to fly out from underneath my teuck while driving by the way it sounds and slips, and now a recall on air bags. The net annual inflow did not fall below 145,000 from 1998 onwards. It hit a peak of 236,000 in 2004. Warning At the base of the reservoir there is a screen that you don't want to damage with your baster.